North America's #1 Pilot Truck Service

PERMITS: 

Idaho oversize permits are valid for five days.

​

OPERATING TIME: 

One half hour before sunrise to one-half hour after sunset, including Saturdays and Sundays (majority of routes).

Up to and including 10′ wide, 110′ long or 14′-6″ high, travel is allowed 24/7 (majority of routes) with

lighting as specified on permit.

Weekend travel is allowed on majority of routes during daytime hours.

​

RESTRICTED TRAVEL: 

If over 13′ wide, movement prohibited between 6:30 am – 8:30 am, 11:30 am – 1:30 pm and

4:00 pm – 6:00 pm in Boise, Caldwell, Coeur d’Alene, Idaho Falls, Lewiston, Nampa,

Pocatello, Twin Falls, Garden City and Chubbuck.

Holiday travel restrictions may depend on dimension.

​

LEGAL DIMENSIONS

Length:

53′ semi-trailer on National Network

48′ trailer on non-N.N. (“non-designated”)

Note: Several two-lane highways in Idaho are non-designated, including US-12 except in the

Lewiston to Spalding, US-93 from Salmon to Challis, and US-95 from Council to Grangeville.

Divisible loads, trailers exceeding 48’ are only allowed with an annual extra length permit, and the

tractor-trailer off-track measurement must not exceed 5.50 feet (3.00 on a few mountain routes)

Non-divisible loads are covered by single or annual permit, without regard to off-track amount.

Overhang: 

4′ front, 15′ rear

Width: 

8′ 6″

Height: 

14′

Weight: 

80,000 Gross

Single – 20,000

Tandem – 34,000

Tridem – depends on spacings

Steer – 600 pounds per inch of tread width (13,200 pounds with 11″ tires)

Divisible Loads Exceeding 80,000: You can exceed 80,000 gross without a permit on state highways

as long as you are legal on all axle/group weights and you are licensed

for at least the amount of your gross weight.

However, if you need any Interstate routes, you will need to get an Annual Excess Weight Permit.

​

ROUTINE PERMIT LIMITS

Length: 

110′

Width: 

16′

Height: 

15′-6″

Weight:

Single – 33,000 to 22,000*

Tandem – 56,000 to 38,500*

Tridem – 70,500 to 48,000*

Steer – 600 pounds per inch of tread width (13,200 pounds for 11″ tires)

* Group weight maximums depend on route classification, with Interstate routes getting the highest.

Loads exceeding these dimensions or are considered as Super Loads.

 

ESCORTS

On 2-Lane Highways:

Length: 

Over 100′ – one escort

Overhang: 

Over 25′ rear – one escort.

Width:

Over 12′ – one escort

Over 14′ – two escorts

Over 16′ – may require three escorts

Height: 

Over 16′ – one escort.

On Interstate System:

Length: 

Over 120′ – one escort.

Overhang: 

Over 25′ rear – one escort.

Width:

Over 15′ – one escort

Over 16′ – may require two or three escorts

Height: 

Over 16′ – one escort.

 

MISCELLANEOUS: 

All lift axles must be on the ground if exceeding legal axle weights.

Blades, buckets, etc. may be taken off and hauled on the same load, depending on route and situation.

State will determine on a case-by-case basis.

​

SIGNS, FLAGS & LIGHTS: 

Requirements are specified on Idaho permit.

“Oversize Load” signs are required on all overwidth loads.

Flags are required on all four corners and extremities of overwidth loads and on rear overhang exceeding 4′. 

Overweight only loads do not require signs or flags.

​